Solar Water Heater Maintenance Checklist

Turn off cold water supply and open drain valve.

Solar water heater maintenance checklist.

Here are some suggested inspections of solar system components. Solar water heating system maintenance and repair periodic inspection list. Let the water run until it stops flowing. Close drain valve and open cold water supply valve.

Checking the solar collectors and frames for damage noting broken or leaking tubes for replacement ensuring valves are in proper positions inspecting pipe insulation to minimize losses and maintain freeze protection checking mounting connectors for. Be sure to check the water draining out and make sure it is clear. If it is then you are set to refill the tank. If water is milky drain entire tank.

Regularly scheduled maintenance should include. 1 temperature of hot water. Annual water heater maintenance checklist drain and flush tank drain and flush tank very important for gas water heaters. Whether the tank is gas or electric turn off its heating source the night before.

When calling for assistance please have the following. Satisfactory not satisfactory 2 quantity of hot water supply. Two major factors affecting the performance of properly sited and installed solar. Solar hot water heaters are no different except that because they have more components there is more that can go wrong.

Before you begin inspect all of the valves. Use a solution of dish soap and warm. Turn off the heat. Drain 2 3 gallons of water.

Check to make sure the water to the hot water heater has been completely shut off. Satisfactory not satisfactory 3 constant temperature e g. Allow a few gallons worth of water to drain. Solar storage tank water heater installation instructions and use care guide to obtain technical warranty or service assistance during or after the installation of this solar storage tank water heater reference the phone number on the warranty sheet that ships with the water heater.

Open t p relief valve to relieve pressure. Open a hot water. Disconnect the hot water heater at the hot water discharge. With pressure valve still open turn on the water to the water tank and then turn on the water drain to allow the rest of the sediment to be flushed out.

Also read your owner s manual. The pump should be installed so that the pump is pumping away from the hot water heater towards the solar panel. Install pump onto the water heater discharge using pipe fitting. Among the parts that should be checked regularly on your solar water heater are pumps valves and their controls insulation wiring pipes seals and the state of the solar collector.

Preventing scaling and corrosion.